Peugeot 406

Since 1996 of release

Repair and car operation

Peugeot 406
+ 1. The maintenance instruction
- 2. Maintenance service
   + 2.1. Petrol models
   - 2.2. Diesel models
      2.2.1. Technical data
      2.2.2. Periodicity of service
      + 2.2.3. Maintenance service
+ 3. The engine
+ 4. Systems of cooling, heating and ventilation
+ 5. Fuel system
+ 6. Ignition system
+ 7. Coupling
+ 8. Transmissions
+ 9. Power shafts
+ 10. Brake system
+ 11. A suspension bracket and a steering
+ 12. A body
+ 13. An electric equipment
+ 14. The basic malfunctions

2.2.2. Periodicity of service

THE GENERAL DATA

That your car was in a fine condition, it is necessary to spend its maintenance service periodically. Service can be spent as constantly, and through certain intervals which are resulted more low. These are the minimum intervals of service recommended by this Management.

Weekly or each 400 km

Check up following elements:

– Oil level in the engine;
– Level of a cooling liquid;
– Level of a brake liquid;
– Water presence in стеклоомывателе;
– A condition of the accumulator, tyres, screen wipers and all bulbs.

Each 10 000 km or 12 months (that will come earlier)

Replace engine oil and the filter.

Merge water from the fuel filter.

Check up all components under a cowl and hoses with liquids.

Check up coupling action.

Check up a condition of consolidations of a power shaft.

Check up a steering and suspension bracket components.

Grease all hinges and locks.
Each 20 000 km

In addition to all points stated above, execute the following:

Replace the filter of pollen of system of ventilation (if it is).

Each 30 000 km

In addition to all points stated above, execute the following:

Replace the air filter.

Replace the fuel filter.

Check up a condition forward and back brake колодок, and also a brake disk and if necessary replace them (models with disk brakes).

Check up action of a manual brake.

Each 60 000 km

In addition to all points stated above, execute the following:

Check up a condition auxiliary приводного a belt and if necessary replace.

Check up level of oil of a mechanical transmission and if necessary add.

Check up a condition back brake колодок and if necessary replace (models with brake drums).

Each 60 000 km or 2 years

In addition to all points stated above, execute the following:

Replace a brake liquid.

Each 120 000 km

In addition to all points stated above, execute the following:

Replace a gear belt of a drive.
The prevention
Insistently it is recommended to replace a gear belt to 60 000 km on cars which are used intensively (many short trips, accelerations and braking) since because of rupture of a gear belt there is a serious damage of the engine.

Replace cooling liquid.